- MobileTemp™
- TP04300A ThermoStream®: temperature source.
- Front load style FL30 ThermoChamber™: a portable front-load style chamber.
- Compressed air supply: a compressor, an air receiver, a refrigerated air dryer, a regenerative desiccant dryer, and a dew point sensor.
ThermoStream® (updated: 10/31/2009)
| Device | ThermoStream® |
| Manufacturer | Temptronic Corp. |
| Model | TP04300A-8C32-5 |
| Function | Temperature source |
| Temperature range | -80℃ to +225℃ (60 Hz) -75℃ to +225℃ (50 Hz) |
| Typical temperature transition rate | -55℃ to +125℃: 10 seconds or less +125℃ to -55℃: 10 seconds or less |
| DUT sensor ports | Internal diode, type T and type K thermocouple and 100 ohm platinum RTD |
| Remote interface ports | IEEE-488 RS-232C serial Start test/End test/Stop on first fail (ST/ET/SFF) Ethernet |
| Drivers | LabVIEW and LabWindows |
| Temperature accuracy | ±1℃ |
| Compressed air requirements | Filtered to 5 micro particulate contamination Oil content: < 0.01 ppm by weight filtered to 0.01 micron oil contaminant Dewpoint: <10℃ at 6.3 bars Supply pressure: 6.2 to 7.6 bars Supply flow at minimum supply pressure: 7.2L/s to 14.3 L/s (norminal 25 scfm) Humidity: 0 to 60% (45% nominal) |
| Over temperature protection | +235℃ (factory set) |
| Mobility | Four swivel caster wheels with locks (101.6 mm diameter) static dissipative; rear handle for ease of transport) |
| Refrigerants | HCFC- and CFC-free, non-toxic, non-flammable |
| Power | 200-250 VAC (230 V nominal), 50/60 Hz, 30 A, 1 phase |
| Noise level | <65 dBA |
| Dimension | 724 mm D x 610 mm W x 108 mm H |
| Weight | 236 kg |
ThermoChamber™ (updated: 10/31/2009)
| Device | Front load style ThermoChamber™ |
| Manufacturer | Temptronic Corp. |
| Model | FL30 |
| Function | A portable thermal chamber |
| Temperature range | -40℃ to +150℃ |
| Temperature change range | Ambient to +125℃: 14.3 minutes +125℃ to ambient: 9.2 minutes Ambient to -40℃: 18.7 minutes -40℃ to ambient: 14 minutes |
| ThermoCouple connections | 10 |
| Shelves | 1 |
| Linear cable feedthrough ports (port lengths 19 cm) |
2 |
| Inner dimension | 510 mm D x 406 mm W x 406 mm H |
| Outer dimension | 635 mm D x 510 mm W x 560 mm H |
| Weight | 25.8 kg |
Compressed air supply (updated: 10/02/2010)
| Device | Twin Screw Compressor |
| Manufacturer | Wolf compressor Co. Ltd. |
| Model | W402-10 |
| Function | Compressing air |
| Working pressure | 7 bar |
| Max. working pressure | 15 bar |
| Air flow level | 1.25 m3 / min for 7 bar, 0.87 m3 / min for 10 bar, or 0.78 m3 / min for 13 bar. |
| Noise level | 68 dB |
| Power | 10 HP/7.5 KW |
| Voltage | 220 V/60 Hz |
| Device | Air receiver |
| Manufacturer | Shim Lie Hunt Co. Ltd. |
| Model | Stand |
| Function | Storing compressed air |
| Max. A.W.P. | 10 kg cm-2 |
| Hyadrostic test | 16 kg cm-2 |
| Volume | 0.304 m3 (304 L) |
| Designed temperature | 40℃ |
| Valve seat diameter | 32 mm |
| Material | SS400 |
| Device | Refrigerative Air Dryer |
| Manufacturer | Yu-Chiao Machinery Co. Ltd.（祐僑機械股份有限公司） |
| Model | YC10AS |
| Function | Filter out water from compressed air |
| Used pressure | 10 kg cm-2 |
| Input temperature | 80℃ |
| HP | 1/3 |
| Outlet diameter | 3/4" |
| scfm | 43 |
| Dew point | 2 to 8 oC (1.7 oC by design) |
| Dispose wind | 1.2 nm3 min-1 |
| Condenser | R134 |
| Voltage | 220 V/60 Hz |
| Dimension (mm) | 700 (L) x 400 (W) x 650 (H) |
| Weight | 57 kg |
| Device | Regenerative Desiccant Air Dryer |
| Manufacturer | Hyper Dryer Machinery Co. Ltd.（高乾機械股份有限公司） |
| Model | F-10M |
| Function | Filter out water from compressed air |
| Used pressure | 0.7 to 1 MPa (10 Kg/cm2) |
| Input temperature | <45℃ |
| HP | 1 |
| Outlet diameter | 3/4" |
| Max flow rate | 1.3 m3/min |
| Dew point | -40 to -70 oC |
| Voltage | 220 V/60 Hz and 1A |
| Dimension (mm) | 510 (L) x 500 (W) x 1475 (H) |
| Device | Dew point sensor mobile |
| Manufacturer | BEKO Technologies GmbH |
| Model | METPOINT DP 207 |
| Function | Measure dew point of compressed air. |
| Dew point pressure | -80℃ to +45℃ td |
| Humidity | 0 to 100 %RH |
| Operating temperature | -20℃ to +70℃ |
| Pressure range | Installation without measuring chamber: –1 to 50 bar Installation with a measuring chamber: up to 16 bar |
| Power supply | Internal Internal NiMH battery for approx. 15 h of operation, indication ”Low Bat. Max 2 h”, residual operating time, charging time: max. 2 h |
| Power supply unit | Input: 110 - 240 VAC, 50 - 60 Hz, 0.2 A Output: 24 VDC, 300 mA, safety category 2, for application in dry places only |
| Weight | 340 g |